Product ID:1571 ROSIN FLUX
MSDS Date:01/01/1992
FSC:3439
NIIN:01-104-7808
MSDS Number: BSVZY

Emergency Phone: 708-297-1600

Info Phone: 708-297-1600

Cage: 09185

Telephone: 847-297-1600

Cage: 75297

NO INGREDIENT FOR THIS FORMULATION_INGREDIENT

LD50 LC50 Mixture:LD50 (ORAL, RAT)=4.9G/KG.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:IRRIT OF MUCOUS MEMBRANES,
PULMONARY SYSTEM. SKIN:LOCAL IRRIT. EYE:IRRIT FROM CONTACT W/LIQUID
& SMOKE FROM SOLDERING. INGEST:BURNING SENSATION IN DIGESTIVE
TRACT. CHRONIC:SKIN:RASH. INHAL :CNS EFFECTS. SMOKE DURING
SOLDERING WILL CONTAIN ROSIN WHICH IS AN ALLERGEN & CAN CAUSE
PULMONARY IRRIT & DAMAGE.
Effects of Overexposure:INHAL:COUGHING, SNEEZING, RUNNY NOSE, HEADACHE,
DIZZINESS, NARCOSIS, NAUSEA. SKIN:REDNESS, ITHCING, RASH.
EYE:TEARING, REDNESS. INGEST:BURNING SENSATION IN DIGESTIVE TRACT.
Medical Cond Aggravated by Exposure:CHEMICAL HYPERSENSITIVITY, ASTHMA &
OTHER RESPIRATORY CONDITIONS. CONTINUED BREATHING OF HIGH
CONCENTRATIONS OF ALCOHOL VAPORS CAN AFFECT LIVER & CNS.

First Aid:EYE:FLUSH W/PLENTY OF WATER. REMOVE ROSIN FROM AROUND EYES
W/DILUTE ETHANOL SOLUTION. SKIN:WASH THOROUGHLY W/SOAP & WATER.
INHAL:REMOVE TO FRESH AIR. INGEST:INDUCE VOMTING & GET PROMPT
MEDICAL ATTENTI ON.

Flash Point Method:TOC
Flash Point:=18.3C, 65.F
Lower Limits:2.5
Upper Limits:15.0
Extinguishing Media:CARBON DIOXIDE, ALCOHOL FOAM, DRY CHEMICAL.
Fire Fighting Procedures:USE WATER SPRAY TO COOL FIRE EXPOSED
CONTAINERS AND CONTROL VAPORS.
Unusual Fire/Explosion Hazard:A MODERATE EXPLOSION HAZARD EXISTS WHEN
EXPOSED TO HEAT OR FLAMES. PRDUCT MAY CAUSE STATIC DISCHARGE.

Spill Release Procedures:REMOVE ALL IGNITION SOURCES. PROVIDE ADEQUATE
VENTILATION. ABSORBENTS SUCH AS VERMICULITE CAN BE USED TO SOAK UP
SPILLED LIQUID. CLEAN UP RESIDUAL WITH ALKALINE DETERGENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE AWAY FROM SOURCES OF IGNITION.
STORAGE AT TEMP BELOW 40F(4C) MAY RESULT IN PRECIPITATION OF SOME
ROSIN.
Other Precautions:OPEN CONTAINERS CAUTIOUSLY TO ALLOW VENTING OF ANY
INTERNAL PRESSURE.

Respiratory Protection:NOT NORMALLY REQUIRED. WHEN VENTILATION IS NOT
ADEQUATE TO REMOVE SMOKE FROM THE BREATHING ZONE, A CARTRIDGE TYPE
RESPIRATOR SHOULD BE WORN.
Ventilation:PROVIDE ADEQUATE EXHAUST VENTILATION(GENERAL AND/OR LOCAL)
TO MEET TLV REQUIREMENTS.
Protective Gloves:PLASTIC, RUBBER.
Eye Protection:SAFETY GLASSES, GOGGLES.
Other Protective Equipment:PLASTIC OR RUBBER APRON WHEN SPLASHING IS
LIKELY TO OCCUR. EYEWASH, SAFETY SHOWER.
Work Hygienic Practices:WASH HANDS THOROUGHLY BEFORE EATING OR SMOKING.
Supplemental Safety and Health

HCC:F2
Boiling Pt:=76.7C, 170.F
Vapor Pres:40
Vapor Density:1.8
Spec Gravity:0.892
Evaporation Rate & Reference:1.8, BUAC=1
Solubility in Water:APPRECIABLE
Appearance and Odor:AMBER STICKY LIUQID WITH AN ALCOHOL ODOR.
Percent Volatiles by Volume:70

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING MATERIALS.
Stability Condition to Avoid:HEAT, FLAMES.
Hazardous Decomposition Products:WHEN HEATED TO SOLDERING TEMP SOLVENT
ARE EVAPORATED & ROSIN MAY BE THERM DEGRADED TO GIVE ALIPH
ALDEHYDES,ACIDS,TERPENE

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FED/STATE/LOCAL
REGULATIONS, USUALLY BY INCINERATION. EPA HAZ WASTE NO D001; HAZ
CLASSE:IGNITABLE WASTE.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.